Note: Ingredients listed on restricted chemical lists
EC/CAS
7440-44-0
Name of the chemical
Carbon black
Concentration
3-10
EC/CAS
7782-42-5
Name of the chemical
Graphite
Concentration
20-40 3-6 1-5
General Information
Revision date
2021-05-05
Product name
45/70 Blank Cartridges
1.2.1 Relevant identified uses
Blank Cartridges for Bridger TM Line Throwing Gun made by Naval Co. Inc
Emergency telephone
352-323-3500
Icons in SDS
Company Information
company name
Naval Company, Inc
e-mail address of the competent person responsible for the Safety Data Sheet
sales@navalcompany.com
GHS Information
Signal word
Warning
Section 2
SECTION 2: Hazards identification
Be sure to thoroughly read and understand the Instructions and Safety Precautions included with the Bridger Line Throwing Gun kit.
Hazard categories
Explosive Division 1.4
Signal word
Warning
Hazard statements
H204 Fire or projection hazard
Prevention
P210 Keep away from heat, sparks, and open flames – NO smoking. P234 Keep only in original package P240 Ground/bond container and receiving equipment. P250 Do not subject to grinding/shock/friction P280 Wear protective gloves/protective clothing/eye protection/face protection.
Response
P370+P372+P380 In case of fire: Explosion risk. Evacuate area. DO NOT fight fire when fire P373 reaches explosives. P370+P380+P375 In case of fire: Evacuate area. Fight fire remotely due to the risk of explosion.
Storage
P401 Store in accordance with industry standards for safe storage.
Disposal
P501 Follow the waste disposal requirements of your country, state, or local authorities.
2.1 Classification of the substance or mixture
Classified As Hazardous Based On IMO and DOT. FIRE AND EXPLOSION: DO NOT FIGHT FIRES. Black powder may deflagrate or explode in a fire while confined. EVACUATE AREA. INJURY FROM DETONATION: Seek prompt medical attention! OTHER: Black Powder Blank Cartridges are explosive, and detonation may cause severe physical injury, including death. All explosives are dangerous and must be handled carefully and used following approved safety procedures under the direction of competent, experienced persons in accordance with all applicable federal, state, and local laws, regulations, and ordinances. Explosives Temps (5 Sec) – Ignited Approximately 427ºC (801ºF) Velocity in the open: trains of black powder usually burn very slowly, measurable in seconds per foot. Confined, as in steel pipe, speeds of explosions have been times at values from 560 feet per second for very coarse granulations to 2.070 feet per second for finer granulations. Confinement and granulation will affect the values. CHRONIC EFFECTS OF OVEREXPOSURE: None APPEARANCE: COLOR: Sealed blank brass cartridge (cylindrical tube) contains black granular powder and primer. PHYSICAL STATE: Solid ODOR: No detectable odor.
