2K SPEED URETHANE CLEAR - PART A

Appearance/Odor

Pale yellow liquid with mild odor = SECTION IV - FIRE AND EXPLOSION HAZARD DATA = FLASH POINT (Deg F): 1 METHOD USED: TOC FLAMMABLE LIMITS IN AIR BY % VOLUME- LOWER: .9 UPPER: 12.8 EXTINGUISHING MEDIA: FOAM, CO2, DRY CHEMICAL SPECIAL FIREFIGHTING PROCEDURES Use approved self-contained breathing apparatus. Cool fire exposed containers with water. UNUSUAL FIRE AND EXPLOSION HAZARDS Keep away from heat, electrical equipment, sparks and open flame. Closed containers may explode when exposed to extreme heat due to pressure build-up. Page: SECTION Vi - PRECAUTIONS FOR SAFE HANDLING AND USE STEPS TO BE TAKEN IN CASE MATERIAL IS RELEASED OR SPILLED ELIMINATE ALL SOURCES OF IGNITION. ABSORB WITH INERT MATERIAL (SAND, VERMICULITE, ETC.), SWEEP OR SCOOP UP AND PUT iN DISPOSAL CONTAINER. FLUSH AREA OF SPILL WITH WATER. WASTE DISPOSAL METHOD Waste must be disposed of in accordance with federal, state and local environmental control regulations. incineration is the preferred method. Empty containers must be handled with care due to product residue and flammable solvent vapor. Decontaminate containers prior to disposal. DO NOT HEAT OR CUT EMPTY CONTAINER WITH ELECTRIC OR GAS TORCH. PRECAUTIONS TO BE TAKEN IN HANDLING AND STORING Keep away from heat, sparks and open flame. Ground containers during storage and transfer operations. Stere in tightly closed containers to prevent moisture contamination. Do not reseal if contamination is suspected. Avoid contact with skin and eyes. OTHER PRECAUTIONS Do not take internally. Avoid prolonged contact. Ground equipment to prevent accumulation of staftic charge. = SECTION Vil - CONTROL MEASURES =: RESPIRATORY PROTECTION Use self-contained breathing apparatus where vapor concentration may be above TLV limits. Below TLV limits, use a combination vapor and particulate respirator for spray application or a vapor respirator for non-spray applications. VENTILATION Exhaust ventilation sufficient to keep the airbome concentration of the solvents, HDI and polyisocyanate below their respective TLV's must be utilized. PROTECTIVE GLOVES Chemical resistant gloves. Cover as much of the skin area as possibie with appropriate clothing. EYE PROTECTION Safety glasses, splash goggles or face shield. Contact lenses should not be wom. OTHER PROTECTIVE CLOTHING OR EQUIPMENT Safety showers and eyewash stations should be provided. WORK/HYGIENIC PRACTICES Wash hands thoroughly before eating or using the washroom. Smoke in smoking areas only. = SECTION IX - REGULATORY INFORMATION =: CALIFORNIA PROPOSITION 65 This product contains a chemical known to the State of California to cause birth defects or other reproductive harm. Contains: Toluene and Benzene (Trace). This product contains a chemical known to the State of California to cause cancer. Contains: Benzene (Trace) and Styrene Oxide. Page: 2 SECTION V - REACTIVITY DATA STABILITY: STABLE CONDITIONS TO AVOID Excessive heat, sparks or open flames INCOMPATIBILITY (MATERIALS TO AVOID) Strong oxidizing agents, isocyanates and acids. HAZARDOUS DECOMPOSITION OR BYPRODUCTS Thermal decomposition may vield CO and/or CO2, oxides of nitrogen amines & other aliphatic fragments. HAZARDOUS POLYMERIZATION: WiLL NOT OCCUR = SECTION V1 - HEALTH HAZARD DATA = INHALATION HEALTH RISKS AND SYMPTOMS OF EXPOSURE Inhalation: Excessive inhalation of vapors may cause nasal and respiratory irritation, dizziness, weakness, fatigue, nausea and headache. High concentrations may result in narcosis. SKIN AND EYE CONTACT HEALTH RISKS AND SYMPTOMS OF EXPOSURE Skin contact may cause irritation. Symptoms of skin irritation may be reddening, swelling, scaling or blistering. Eye contact may cause tearing, reddening and swelling of the eyes. SKIN ABSORPTION HEALTH RISKS AND SYMPTOMS OF EXPOSURE Skin absorption may cause systemic effects similar fo those identified under inhalation effects. INGESTION HEALTH RISKS AND SYMPTOMS OF EXPOSURE Ingestion: May cause gastrointestinal irritation, nausea, vomiting and diarrhea. Aspiration of material into lungs can cause chemical pneumonitis which can be fatal. HEALTH HAZARDS {(ACUTE AND CHRONIC) Acute: Hay cause eye, nose and skin irritation, headache, dizziness and nausea. ingestion may result in vomiting; aspiration of liquid into the lungs may result in aspiration pneumonitis. Chronic: Long term exposure may lead to central nervous system depression and dermatitis. CARCINOGENICITY NTP CARCINOGEN No IARC MONOGRAPHS Yes OSHA REGULATED: Yes This material contains styrene oxide, which is classified as a possible carcinogen for humans (2B} by IARC. This material contains ethylbenzene which is classified as "possibly carcinogenic to humans” (2B) by IARC. MEDICAL CONDITIONS GENERALLY AGGRAVATED BY EXPOSURE Pre-existing eye, skin and respiratory disorders may be aggravated.