Black Jack Roof Cement

Hazardous Ingredients

------------------------------------------------------------------------------ CHEMICAL NAME OSHA-PEL ACGIH-TLV LD50/LC50 %WT/WT Mineral Spirits 500 ppm 100 ppm ND 10-30 2900 mg/m3 525 mg/m3 - CAS #8052-41-3 CARCINOGEN: NO ======================================================== SECTION III PHYSICAL DATA ------------------------------------------------------------------------------ APPEARANCE, PHYSICAL STATE AND ODOR: Black coarse paste, solvent odour. ODOR THRESHOLD (PPM): ND SPECIFIC GRAVITY/DENSITY (G/ML): 1.11-1.21 VAPOR PRESSURE (MM): 2 mm @ 25’C VAPOR DENSITY (AIR=1): >1 EVAPORATION RATE (BUAC=1): <1 BOILING POINT: 310 Deg. F./154 Deg. C. MELTING/FREEZING POINT: NA PH: NA COEFFICIENT OF WATER/OIL DISTRIBUTION: ND SOLUBILITY IN WATER: Nil % VOLATILE BY VOLUME: 20-30 ======================================================== SECTION IV FIRE OR EXPLOSION DATA ------------------------------------------------------------------------------ FLASH POINT: 40 Deg. C. Min. TCC AUTO IGNITION TEMPERATURE: 254 Deg. C. SENSITIVITY TO MECHANICAL IMPACT: ND EXPLOSIVE POWER: ND UPPER EXPLOSION LIMIT: 7.0% by vol. LOWER EXPLOSION LIMIT: .8% by vol. RATE OF BURNING: ND SENSITIVITY TO STATIC DISCHARGE: ND EXTINGUISHING MEDIA: Foam, carbon dioxide, and dry chemical SPECIAL FIRE FIGHTING PROCEDURES: Do not direct a solid stream of water into hot asphalt. Water may cause frothing, apply cautiously. UNUSUAL FIRE AND EXPLOSION HAZARDS: NA UNDER WHAT CONDITIONS: B3 ======================================================== SECTION V REACTIVITY DATA ------------------------------------------------------------------------------ STABILITY - MATERIAL IS: Stable CONDITIONS TO AVOID: Heat, sparks, flames HAZARDOUS DECOMPOSITION/COMBUSTION PRODUCTS: Carbon dioxide, carbon monoxide INCOMPATIBILITY (MATERIALS TO AVOID): Strong oxidising agents HAZARDOUS POLYMERIZATION: Will not occur ======================================================== SECTION VI TOXICOLOGICAL PROPERTIES ------------------------------------------------------------------------------ PRIMARY ROUTES OF ENTRY: Inhalation - Skin - Ingestion EFFECTS OF OVEREXPOSURE, CHRONIC: Prolonged/repeated skin contact may cause dermatitis. EFFECTS OF OVEREXPOSURE, ACUTE: Skin Prolonged/repeated contact may cause irritation. Eyes May cause slight irritation. Inhalation Excessive breathing of high vapour concentration may cause headache, dizziness, and nausea. Ingestion: Nausea, vomiting, headache and dizziness. MEDICAL CONDITIONS GENERALLY AGGRAVATED BY EXPOSURE: Pre-existing skin disorders CARCINOGENICITY: NO LD50 OF PRODUCT: ND LC50 OF PRODUCT: ND IRRITANT: In some cases SENSITIZER: NO SYNERGISTIC MATERIALS: NA REPRODUCTIVE EFFECTS: NO TERATOGENIC: NO MUTAGENIC: NO WHMIS CLASSIFICATION: D2 ======================================================== SECTION VII PREVENTIVE MEASURES, SAFE HANDLING AND USE, REGULATORY INFORMATION ------------------------------------------------------------------------------ LEAK AND SPILL PROCEDURES: Dike spill area. Add absorbent to spill area. Remove sources of ignition. Ventilate area if necessary. WASTE DISPOSAL METHOD: Dispose of according to Federal, State and Local regulations. PRECAUTIONS TO BE TAKEN IN HANDLING AND STORAGE: Keep away from sources of ignition. Keep container closed when not in use. Use with adequate ventilation. Avoid prolonged inhalation of mist or vapour. Avoid prolonged/repeated skin contact. OTHER: Keep out of the reach of children! VENTILATION: As necessary to maintain exposure below TLV RESPIRATORY PROTECTION: Not normally required in well ventilated area. A NIOSH/MESA approved breathing apparatus is recommended if TLV is exceeded. PROTECTIVE GLOVES: Solvent and Oil resistant EYE PROTECTION: Not normally needed OTHER PROTECTIVE EQUIPMENT: Solvent resistant apron and boots if contact is likely WORK/HYGIENIC PRACTICES: Remove contaminated clothing, launder before reuse. RCRA HAZARDOUS WASTE NO: (FED) D001 DOT PROPER SHIPPING NAME: Liquid Tars DOT HAZARD CLASS: UN1999 VOLATILE ORGANIC COMPOUNDS (VOC): <220 G/L TDG CLASSIFICATION (CAN): Class 3 PG III (General Exemption 1.33 for domestic Shipments ) ======================================================== SECTION VIII FIRST AID MEASURES ------------------------------------------------------------------------------