Chlorine

Physical hazards

Oxidizing gases Category 1 Gases under pressure Liquefied Gas

Health hazards

Acute toxicity, inhalation Category 2 Skin corrosion Category 1 Serious eye damage Category 1 Specific target organ toxicity, single Category 3 respiratory tract exposure irritation Specific target organ toxicity, repeated Category 1 (lung) exposure

Environmental hazards

Not currently regulated by OSHA, refer to Section 12 for additional information. OSHA defined hazards This mixture does not meet the classification criteria according to OSHA HazCom 2012.

Signal word

Danger

Hazard statements

Contains gas under pressure; may explode if heated. Fatal if inhaled. Causes severe skin burns and eye damage. May cause respiratory irritation. May cause or intensify fire; oxidizer. Very Toxic to aquatic life. Causes damage to organs through prolonged or repeated exposure.

Prevention

Do not breathe dust, fume, gas, mist, vapors, spray. Use only outdoors or in a well-ventilated area. Wear respiratory protection. Wash hands and face thoroughly after handling. Wear protective gloves, protective clothing, eye protection, face protection. Do not eat, drink or smoke when using this product. Keep/store away from clothing and other combustible materials. Keep reduction valves/valves and fittings free from oil and grease.

Response

Immediately call a POISON CENTER or doctor/physician. IF INHALED: Remove person to fresh air and keep comfortable for breathing. IF SWALLOWED: Rinse mouth. Do NOT induce vomiting. IF ON SKIN (OR HAIR): Take off immediately all contaminated clothing. Rinse skin with water/shower. Wash contaminated clothing before reuse. IF IN EYES: Rinse cautiously with water for several minutes. Remove contact lenses, if present and easy to do. Continue rinsing. In case of fire: Stop leak if safe to do so.

Storage

Protect from sunlight. Store in a well-ventilated place. Keep container tightly closed. Store locked up.

Disposal

Dispose of contents/container in accordance with local/regional/national/international regulations. Hazard(s) not otherwise No OSHA defined hazard classes.

Other hazards which do not result in classification

Toxic fumes, gases or vapours may evolve on burning. Chlorine is extremely corrosive to most metals in the presence of moisture (>150 ppm water) or at high temperatures. Combines with water to produce hydrochloric and hypochlorous acid. Severe, short-term exposures may cause long-lasting respiratory effects, e.g. Reactive Airways Dysfunction (RADS), due to the material's severe irritating properties. Contact with liquefied gas might cause frostbites, in some cases with tissue damage. Direct contact with liquefied gas may cause frostbite and corrosive injury to the eyes.

Additional information

Keep away from heat. Use smallest possible amounts in designated areas with adequate ventilation. Liquid chlorine lines must have suitable expansion chambers between block valves due to high coefficient of expansion. Establish written emergency plan and special training where chlorine is used. Regularly inspect and test piping and containers used for chlorine service.