CLYDSPIN

SECTION 2: Hazards identification

Classification under CLP Classification of the substances or mixture

2.2 Label elements

This product has no label elements

PBT Substances

The substances in this product are not identified as a PBT / vPvB substances

2.1 Classification of the substance or mixture

2.1.1 Classification according to Regulation (EC) No. 1272/2008 (CLP) This product has no classification under CLP 2.1.2 Additional information The product contains Mineral Oil with less than 3% DMSO extract as measured by IP346. 2.2 Label elements This product has no label elements 2.3 Other hazards PBT: The substances in this product are not identified as a PBT / vPvB substances. 3. COMPOSITION / INFORMATION OF INGREDIENTS Clydspin lubricating grease substances Graphite flakes CAS No. 7782-42-5 Approx 15% Mineral Oil CAS No. 64742-52-5 & CAS No. 64742-54-7 Approx 70- 85% 4. FIRST AID MEASURES INHALATION: Move to fresh air in case of accidental inhalation of vapours. Obtain medical advice if irritation continues. SKIN CONTACT: Wash with soap and water. Change contaminated clothing and launder before re-use. EYE CONTACT: Bathe the eye with running water for 15 minutes. Obtain medical advice if redness and/or irritation persists. INGESTION: Wash out mouth with water. Do not induce vomiting because of the danger of aspiration. Obtain medical advice if aspiration occurs. 5. FIRE FIGHTING MEASURES EXTINGUISHING MEDIA: Suitable extinguishing media for the surrounding fire should be used. Carbon dioxide. Dry chemical powder. Wa- ter spray. Alcohol or polymer foam. EXPOSURE HAZARDS: In combustion emits toxic fumes of carbon dioxide / carbon monoxide. SPECIFIC HAZARDS: Evaluation of gases and particulates (see section 10). SPECIAL PROTECTIVE EQUIPMENT: Wear breathing apparatus for fires in closed or confined spaces. 6. ACCIDENTAL RELEASE MEASURES PERSONAL PRECAUTIONS: May cause slippery surfaces. ENVIRONMENTAL PRECAUTIONS: Contain spillage – do not wash down drain. Report any escape to public drainage or water courses to local authority and Fire Brigade RECOVERY: Absorb into dry earth or sand. Mix with sand or vermiculite. Transfer to a closable, labelled salvage container for disposal by an appropriate method. 7. HANDLING AND STORAGE HANDLING REQUIREMENTS: Ensure there is sufficient ventilation of the area. Avoid the formation or spread of mists in the air. Avoid direct contact with the substance. STORAGE CONDITIONS: Store in cool, well ventilated area. Prevent the build up of electrostatic charge in the immediate area. Avoid incompatible materials and conditions - see section 10 of SDS. SUITABLE PACKAGING: Must only be kept in original packaging. 8. EXPOSURE CONTROLS / PERSONAL PROTECTION OCCUPATIONAL EXPOSURE STANDARD: HSE Guidance Note “Working safely with metalworking fluids” respiratory illness and cancer from mineral oils. (http://www.hse.gov.uk/pubns/indg365.pdf). See also https://www.osha.gov/dts/chemicalsampling/data/CH_258700.html (accessed 24/1/2018) RESPIRATORY PROTECTION: Unlikely to be required in normal use, ensure sufficient ventilation. If the product is exposed to heat and an operator is exposed to vapours then a suitable air-purifying respirator with an N100, R100, or P100 filter should be worn. HAND PROTECTION: Wear gloves (nitrile rubber or neoprene) for repeated exposure. EYE PROTECTION: Wear eye protection if splashing is likely. 9. PHYSICAL AND CHEMICAL PROPERTIES APPEARANCE : Black Semi-Solid Grease STATE: Paste ODOUR: Odourless FLASH POINT: > 93ºC BOILING POINT/RANGE: >35ºC RELATIVE DENSITY: 0.82-0.85 SOLUBILITY (WATER): Insoluble 10. STABILITY AND REACTIVITY REACTIVITY: Stable under recommended transport or storage conditions. CHEMICAL STABILITY: Stable under normal conditions. CONDITIONS/MATERIALS TO AVOID: Heat. Sources of ignition. Flames. Strong oxidising agents. HAZARDOUS DECOMPOSITION PRODUCTS: In combustion emits toxic fumes of carbon dioxide / carbon monoxide. 11. TOXICOLOGICAL INFORMATION INHALATION: Unlikely to be irritant under normal conditions but there may be irritation of the throat with a feeling of tightness in the chest. SKIN CONTACT: There may be mild irritation at the site of contact. EYE CONTACT: May cause irritation with short-term redness and stinging. INGESTION: There may be soreness and redness of the mouth and throat. There may be vomiting and diarrhoea. 12. ECOLOGICAL INFORMATION No information available, but can be expected to biodegrade slowly. Negligible ecotoxicity. 13. DISPOSAL CONSIDERATIONS DISPOSAL OPERATIONS: Transfer to a suitable container and arrange for collection by specialised disposal company. WASTE CODE NUMBER: 12 01 12 DISPOSAL OF PACKAGING: Arrange for collection by specialised disposal company. NB: The user’s attention is drawn to the possible existence of regional or national regulations regarding disposal. 14. TRANSPORT INFORMATION This product does not require a classification for transport. 15. REGULATORY INFORMATION SUPPLY CLASSIFICATION : Not Classified as Hazardous for supply. 16. OTHER INFORMATION This safety data sheet is prepared in accordance with the REACH DIRECTIVE 1907/2006 Annex II. Every effort has been made to ensure that the information in this Safety Data Sheet is accurate and reliable, but the company cannot accept liability for any loss, injury or damage, which may result from its use. Data given in this Safety Data Sheet is solely for the guidance in safe handling and use of the product by customers - they do not constitute a specification. Customers are reminded that there may be applications of our products, which are protected by patent, under which they have no rights whatsoever. If any difficulties should arise, we will be happy to discuss them. Customers are encouraged to carry out their own tests. Before using any product, read the label carefully. Legal disclaimer: The above information is believed to be correct but does not purport to be all inclusive and shall be used only as a guide. This company shall not be held liable for any damage resulting from handling or from contact with the above product.