Activated Carbon

Principle Routes of Exposure

Ingestion: Carbon is non-toxic through ingestion Inhalation: The physical nature of carbon may irritate the respiratory system Skin: Carbon is non-toxic through skin absorption Eye Irritation: The physical nature of carbon may cause, eye irritation. EMERGENCY & EIRST AID PROCEDURES: In case of inhalation remove to fresh air. Administer first aid as appropriate. Seek medical attention. In case of ingestion do not induce vomiting. Dilute by giving water or milk. Seek medical attention. Skin Contact: Wash thoroughly with water. If irritation persists seek medical attention. In case of eye contact flush with lukewarm water for at least 15 minutes. Seek medical attention. OTHER: The effects of chronic and sub-chronic exposure have not been determined. Safe handling on a long-term basis should emphasize protection against respective or long-term exposure to carbon dust inhalation and avoidance of contact to any liquids that may leach off the impregnated carbon. FIRE FIGHTING MEASURES Flashpoint: Not Applicable. Non-flammable: 16CFR1500.44. Not Self Heating: UN Manual of Tests and Criteria, Test N.3. Flammability Limits in Air: LFL and UFL Not Applicable. GENERAL HAZARD: Activated carbon is difficult to ignite and tends to burn slowly (smoulder) without producing smoke or flame. Toxic gases will form upon combustion. FIRE FIGHTING INSTRUCTIONS: If possible to do safely, move smouldering activated carbon to a non-hazardous area, preferably out of doors. Extinguish fire using water fog, fine water spray, carbon dioxide or foam. Avoid stirring up dust clouds. FIRE FIGHTING EQUIPMENT: Fire fighting personnel should wear full protective equipment, including self-contained breathing apparatus (SCBA) for all inside fires and large outdoor fires. HAZARDOUS COMBUSTION PRODUCTS: Combustion products may include smoke and oxides of carbon (for example, carbon monoxide). Materials allowed to smoulder for long periods in enclosed spaces, may produce amounts of carbon monoxide which reach the lower explosive limit (carbon monoxide LEL = 12.5% in air). Under certain conditions, any airborne dust may be an explosion hazard. Used activated carbon may produce additional combustion products. REACTIVITY DATA: Incompatibility. Avoid strong oxidizers and liquid acids. Stable: Yes Conditions to avoid: None Hazardous Decomposition Products: Oxides of Carbon Hazardous Polymerization: Will not occur SPILL & LEAK PROCEDURES: Reportable Quantities: No EPA requirements Steps to be taken in the event if a spill: Sweep up, neutralize and discard in protected refuse container. Do not release to sewer or waterway. Waste Disposal Method: Unused product may have a lot pH. Used product may contain hazardous chemicals or hazardous properties that may have to be examined to determine proper disposal method. Dispose of in accordance with local, stare, and federal regulations Disposal Considerations: Activated carbon, in its original state, is not a hazardous material or hazardous waste. Follow applicable governmental regulations for waste disposal. Used activated carbon may become classified as a hazardous waste depending upon the application. Follow applicable regulations for disposal. Recycling (reactivation) may be a viable alternative to disposal. Contact Carbon Activated Corp. for information. SPECIAL PROTECTION INFORMATION: Respiratory Protection: Use NIOSH/MSHA approved respiratory protection equipment appropriate to the material and/or its concentration where airborne exposure is likely. If exposures cannot be kept to a minimum with engineering controls, consult respirator manufacturer to determine appropriate type equipment for a given application. Observe respirator use limitations specified by NIOSH/MSHA or the manufacturer. Ventilation/Local Exhaust: Essential in confined areas. Eye Protection: Safety glasses or goggles with side shields are recommended for any type of handling. Where eye contact or dusty conditions may be likely, dust tight goggles are recommended. Have eye flushing equipment available. Engineering Controls: Use local exhaust ventilation to control emissions near the source. Ventilation systems should be sized and configured to prevent exceeding of recommended or regulated exposure limits. Skin Protection: Avoid contact with the skin. Wear appropriate dust resistant clothing. Wash contaminated clothing and clean protective equipment before reuse. Wash skin thoroughly after handling. Protective Gloves Recommended Hygienic Practices: Wash thoroughly after handling. Airborne Exposure Guidelines: Recommended Exposure Limits Activated Carbon 8-hr TWA Total Dust 10 mg/m3* Respirable Fraction 3 mg/m3* *OSHA and ACGIH have not established specific exposure limits for this material. The recommended exposure limits for these activated carbon products are base on the Threshold Limit Values adopted by ACGIH for Particulates (insoluble) Not Otherwise Classified. The OSHA PEL for Nuisance Dust is 15 mg/m3 (5 mg/m3 respirable fraction). STORAGE AND HANDLING INFORMATION: Storage Temperature: Ambient Storage Pressure: Atmospheric Handling: Follow good handling and housekeeping practices to minimize spills, generation of airborne dusts, and accumulation of dusts on exposed surfaces. Use with adequate exhaust ventilation to draw dust away from workers' breathing zones. Prevent or minimize exposures to dusts by using appropriate personal protection equipment. Wash exposed skin areas thoroughly with soap and water after handling. Storage: Dry airtight storage recommended. Maintain good housekeeping. Store away from strong oxidizers such as ozone, liquid oxygen, chlorine, permanganate, etc. ECOLOGICAL AND TOXICOLOGICAL INFORMATION This material, in its original state, is not harmful to the environment. Used activated carbon may exhibit characteristics of the adsorbed material. This material is non-toxic in its original state. Used activated carbon may exhibit characteristics of the adsorbed material. FEDERAL REGULATIONS: OSHA Hazard Communication: See "Particulates not otherwise regulated," in Table Z-1, Standard, 29CFR1910.1200: of 29CFR1910.1000, "Limits For Air Contaminates". CERCLA/SUPERFUND, 40CFR117, 302: Notification of spills of this material is not required. SARA/SUPERFUND: Amendments and Reauthorization Act of 1986 (Title III), Sections 302, and 313:. SECTION 302 - EXTREMELY HAZARDOUS SUBSTANCES (40CFR355): This product is not listed as an extremely hazardous substance. SECTION 313 - LIST OF TOXIC CHEMICALS: This product is not listed. Toxic Substances Control Act, 40CFR710: Activated carbon is on the inventory list. Resource Conservation and Recovery Act: This product, in its original state, does not meet the criteria of hazardous waste. STATE REGULATIONS: California Occupational Safety and Health: • Not listed. Massachusetts Substance List: • Not listed. New Jersey Right-to-Know: • Not listed. Pennsylvania Right-to-Know: • Not listed. HMIS INDEX: HMIS Index details are as follows, HEALTH: 0 FLAMMABILITY: 1 REACTIVITY: 1 PPE: E TRANSPORTATION INFORMATION DOT (Department of Transportation) Proper Shipping (Article) Name: Steam Activated Carbon, Non-Regulated OR Carbon, Activated, Non-Regulated Shipping Class: Class 70 Hazard Class: Not applicable. UN/NA Number: Not applicable. Packing Group: Not applicable. Freight Classification: STCC Code - #2899643 / NMFC #040560 DOT Marking: N/A DOT Placard: N/A Precautions to be taken in Transportation: N/A EMERGENCY ACCIDENT PRECAUTIONS AND PROCEDURES: Contact: Carbon Activated Corporation Australia Phone: 1300 742 223 SPECIAL PRECAUTIONS: Precautions to be taken